即时比分网

木屑顆粒機齒輪箱維護都需求留意哪些問題呢?

來源:http://comicbopk.com 發布時間:2019-10-23 瀏覽次數:
  一,木屑顆粒機制粒室內的高濕蒸汽可能會經過密封圈進入齒輪箱;二,由于齒輪箱工作時是高溫高壓,那么停機冷卻后,齒輪箱內會構成負壓,這樣空氣中的水汽就會進入齒輪箱。經過油位察看鏡發現里面的油假如有乳化現象,闡明就有水了。齒輪箱一旦有水要及時排掉,否則會形成大齒輪小齒軸外表有點蝕現象,減少大齒輪的運用壽命,除此還會影響軸承的光滑效果。每周需求排水一次,停機4-8小時后,水油完整別離后便可排出。假如每周排出的水不多,多能夠放寬到兩周排次水,時間距離不可太長,特別是南方的梅雨時節時期。在消費旺季更要留意排水。
  First, the high humidity steam in the grain chamber of the sawdust particle mechanism may enter the gearbox through the sealing ring; second, because the gearbox works at high temperature and high pressure, the gearbox will form a negative pressure after shutdown and cooling, so the water vapor in the air will enter the gearbox. If the oil in the oil level inspection mirror is emulsified, it is clarified that there is water. Once there is water in the gearbox, it should be drained in time, otherwise there will be pitting on the surface of the small gear shaft of the big gear, reducing the service life of the big gear, which will also affect the smooth effect of the bearing. Drainage is required once a week. After 4-8 hours of shutdown, water and oil can be discharged after separation. If the water discharged every week is not much, it can be relaxed to two weeks at most. The time distance should not be too long, especially in the rainy season in the south. Pay more attention to drainage during the peak consumption season.
木屑顆粒機批發
  木屑顆粒機齒輪箱油定期改換
  Regularly change the oil in the gear box of the sawdust granulator齒輪箱油是用來光滑小齒軸的前后軸承以及空軸的前后軸承的,同時在齒面構成油膜,對大齒輪小齒軸起到了很好的維護作用。油質請求:要到達ISO等級的220#齒輪油,對橡膠和銅無腐蝕。(可參考CPM鋸末顆粒機闡明書新機3個月內必需換油,以后每工作2000小時改換一齒輪箱油容量:3000型是46升,7000型是75木屑顆粒機齒輪箱、磁鐵清每次換油,都要清洗齒輪箱和磁鐵。要用15#的稀機油清洗齒輪箱,齒輪箱內部的清洗要徹底到位,特別是空軸前后軸承上方的兩個進油口,一定要清洗潔凈避免梗塞。
  The gearbox oil is used to smooth the front and rear bearings of the small gear shaft and the front and rear bearings of the empty shaft. At the same time, the oil film is formed on the tooth surface, which plays a good role in maintaining the large gear and small gear shaft. Oil quality requirements: to reach ISO grade 220 × gear oil, no corrosion to rubber and copper. (please refer to the instruction book of CPM sawdust granulator, the new machine must change the oil within 3 months, and then change the oil capacity of a gearbox every 2000 hours: 46 liters for 3000 type, 75 for 7000 type, the gearbox and magnet of sawdust granulator shall be cleaned every time the oil is changed. Use 15 × thin oil to clean the gearbox, and the internal cleaning of the gearbox shall be completely in place, especially the two oil inlets above the front and rear bearings of the empty shaft, which must be cleaned to avoid infarction.
  以上是木屑顆粒機批發廠家為大家介紹的相關內容,想要了解更多內容,歡迎訪問網站:http://comicbopk.comThe above is the relevant content introduced by the sawdust granulator wholesaler. To learn more, please visit the website: http://comicbopk.com

上一篇:生物質顆粒機生產廠家濟南能滿足客戶需求才能發展的更快!

下一篇:秸稈顆粒機廠家直銷:在綠色環保上開辟了一條新道路!

重庆彩票 重庆彩票 重庆彩票 上海时时乐 上海时时乐 专业玩彩 专业玩彩 专业玩彩