即时比分网

不同原料元素對木屑顆粒機產量有什么影響

來源:http://comicbopk.com 發布時間:2019-09-03 瀏覽次數:
  木屑顆粒機隨著開展,應用的中央越來越多,很多人在運用過程中,由于為本人的原料性質不能分明,在這里給大家做一些簡單介、下面就簡單說下:
  With the development of sawdust granulator, more and more central applications, many people in the process of operation, because the nature of their raw materials can not be clearly defined, here to give you some brief introduction, the following is a brief statement:
  1、油脂 增加少數的油脂(0.5%~1%),有利于削減木屑顆粒機部件磨損,并使顆粒容易經過模孔,增加制粒產值.但是當增加量超越2%時,會使顆粒渙散,難以成形.因此,在增加高劑量油脂時,宜在混合機處增加全量的30% ,制粒機處噴涂全量的70%.
  1. Increasing a small amount of grease (0.5%~1%) is beneficial to reduce the wear and tear of wood chips granulator parts, make the particles pass through the die hole easily and increase the output value of granulation. But when the increase exceeds 2%, the particles will be scattered and difficult to form. Therefore, when increasing the high-dose grease, it is advisable to increase the total amount by 30% at the mixer and spray the total amount by 70% at the granulator. %.
木屑顆粒機批發
  2、粗纖維 恰當的粗纖維含量(3%~5%),有利于木屑顆粒料的粘結,削減顆粒的粉化率,增加制粒產值,但粗纖維含量超越10%時,則會由于粘結性差而影響顆粒的硬度和成形率,增加機械磨損,降低制粒產值.木屑顆粒機3、物料水分物料水分含量過高,在制粒時削減蒸汽增加量,影響制粒溫度的進步,然后影響顆粒飼料的產值和質量.一同,物料的水分過高,調質艱難且易構成物料在環模內壁與壓輥之間打滑,致使環模孔阻塞.通常懇求調質前物料水分應在13%以下.
  2. Proper crude fibre content (3%~5%) of crude fibre is conducive to the bonding of sawdust granules, reducing the pulverization rate of particles and increasing the output value of granulation. However, when the content of crude fibre exceeds 10%, the hardness and forming rate of particles will be affected by poor cohesiveness, increasing mechanical wear and reducing the output value of granulation. 3. Sawdust granulator 3. Material moisture and material moisture. Together, the moisture content of the material is too high, and it is difficult to adjust and temper, which makes it easy for the material to slip between the inner wall of the ring die and the pressing roller, resulting in the blockage of the hole in the ring die. Usually, the moisture content of the material should be below 13% before tempering.
  4、蛋白質 物料蛋白質含量高,受熱后物料可塑性大,粘性增加,制粒產值高.但非蛋白氮l如尿素等)高時,制粒產值降低.
  4. Protein material has high protein content. After heating, the plasticity of the material is large, the viscosity is increased and the output value of granulation is high. However, when the non-protein nitrogen, such as urea, is high, the output value of granulation decreases.
  5、淀粉 谷物類淀粉含量高,在高溫、高水分下容易制粒,產值也高,此刻請求調質水分在16%~18%之間.調質溫度應在80℃以上.不然淀粉糊化水平差而發作脆性顆粒,乃至不能成形.若谷物在調質前現已熟化(如烘干玉米),則制粒產值降低.因此,收買質料時以不選擇烘干的為好.
  5. Starch cereals have high starch content, easy to granulate at high temperature and high water content, and high output value. At this moment, conditioning water should be between 16% and 18%. Tempering temperature should be above 80 C. Otherwise, the starch gelatinization level is poor and brittle granules can not be formed. If the cereals are ripe before conditioning (such as dried corn), the grain production value will be reduced. Therefore, it is better not to choose drying when buying materials.
  6、熱靈活飼料 乳糖、乳清粉等受熱后粘性增加,有增加進步產值,但溫度超越60℃,就易呈現焦化,阻塞模孔,影響制粒產值.因此對這類飼料調質時可采用溫水.
  6. Viscosity of hot flexible feed such as lactose and whey powder increases after heating, which increases the output value. However, when the temperature exceeds 60 C, it tends to appear coking, blocking the die holes and affecting the output value of granulation. Therefore, warm water can be used for tempering this kind of feed.
  7、礦物質 無機質飼料簡直無粘結力.制粒功用差,影響制粒產值.因此,當無機質含量高時,通常要向物料中加人少數粘結劑(如糖蜜)以改善制粒功用,增加顆粒機的產值.
  7. Mineral inorganic feed is almost non-cohesive. The poor function of pelletizing affects the output value of pelletizing. Therefore, when the inorganic content is high, a few binders (such as molasses) are usually added to the material to improve the function of pelletizing and increase the output value of the pelletizer.
  濟南龍騰新能源重型設備有限公司生產,玉米,秸稈壓塊機,木屑顆粒機,秸稈煤炭成型機,飼料顆粒機等系列設備歡送您的咨詢。 本文來源:木屑顆粒機批發廠家:http://comicbopk.comJinan Longteng New Energy Heavy Equipment Co., Ltd. specializes in the production of corn, straw compactor, sawdust granulator, straw coal briquetting machine, feed granulator and other equipment to welcome your consultation. Source: Wholesale Manufacturer of Sawdust Granulator: http://comicbopk.com

上一篇:市場混亂我們如何選購購生物質顆粒機

下一篇:生物質顆粒機生產廠家:燃料的質量決定著企業未來的發展

重庆彩票 重庆彩票 重庆彩票 上海时时乐 上海时时乐 专业玩彩 专业玩彩 专业玩彩